中空玻璃設備清洗機是現代玻璃加工企業的必備機器，臥式的中空玻璃加工設備采用水平臥式結構，平板玻璃放置在傳送輥上，經過進料段、清洗段、干燥段、到達出料段，從而制作出中空玻璃。設備的使用必然非常重要，但是昌盛小編認為，清洗機的維護保養工作同樣要引起大家重視。

　　Hollow glass equipment cleaning machine is an essential machine for modern glass processing enterprises. The horizontal hollow glass processing equipment adopts a horizontal structure, and the flat glass is placed on the conveyor roller, passing through the feeding section, cleaning section, drying section, and reaching the discharge section to produce hollow glass. The use of equipment is inevitably very important, but the Changsheng editor believes that the maintenance and upkeep of cleaning machines should also be taken seriously.

　　對中空玻璃設備進行日常維護及保養是非常重要的事情，平時要經常觀察設備的運動部分、水路系統、風路系統、電氣系統，遇有緊急情況立即停車檢查。

　　Daily maintenance and upkeep of insulated glass equipment is very important. It is necessary to regularly observe the moving parts, water system, air system, and electrical system of the equipment. In case of emergency, stop the vehicle immediately for inspection.

　　1、運動部分

　　1. Sports section

　　（1）軸承及潤滑軸承是在機械傳動過程中起固定和減小載荷摩擦系數的部件。也可以說，當其它機件在軸上彼此產生相對運動時，用來降低動力傳遞過程中的摩擦系數和保持軸中心位置固定的機件。大家要對中空玻璃加工設備的各個潤滑點及時進行潤滑。

　　(1) Bearings and lubricated bearings are components that fix and reduce the friction coefficient of loads in mechanical transmission processes. It can also be said that when other components generate relative motion on the shaft, it is used to reduce the friction coefficient during power transmission and maintain the fixed position of the shaft center. Everyone should lubricate the various lubrication points of the insulated glass processing equipment in a timely manner.

　　（2）水路系統的維護中空玻璃加工設備清洗段所用水是循環時用的。每天應更換水箱中的存水，以保證清洗用水的干凈，每月清洗一次水箱及過濾裝置。通過清洗段蓋上的觀察孔可監視噴水情況，如果發現有堵塞現象，則停泵打開箱蓋，拆下噴水嘴，疏通清洗過后安裝。（3）分路系統的維護定期檢查中空玻璃加工設備的鼓風機運行情況，遇有異常聲音時立即停機，報告維修部門檢查。每二個月將進風口的過濾柵進行清洗，平時要保持鼓風機房的清潔，以免灰塵被吸入風路，污染玻璃。

　　(2) The water used for cleaning the hollow glass processing equipment in the maintenance of the waterway system is for circulation. The stored water in the water tank should be replaced daily to ensure the cleanliness of the cleaning water. The water tank and filtration device should be cleaned once a month. By cleaning the observation hole on the section cover, the water spray situation can be monitored. If any blockage is found, stop the pump, open the box cover, remove the water spray nozzle, clear and clean it before installation. (3) Regularly check the operation of the blower in the hollow glass processing equipment for the maintenance of the branching system. If there is any abnormal sound, immediately stop the machine and report to the maintenance department for inspection. Clean the filter grille of the air inlet every two months, and keep the blower room clean to prevent dust from being sucked into the air duct and contaminating the glass.

　　2、水路系統中空玻璃加工設備的水路系統由兩只水箱四套循環水系統組成。洗滌劑箱宜用PH=7的中性玻璃清洗劑，最后一道玻璃漂洗宜用去離子水，水的質量直接影響后玻璃的表面清潔度。洗滌液的溫度一般控制在30～60度（水溫加熱控制裝置用戶自備）。

　　2. The water system of the hollow glass processing equipment in the water system consists of two water tanks and four sets of circulating water systems. Neutral glass cleaner with pH=7 should be used for the detergent box, and deionized water should be used for the final glass rinse. The quality of water directly affects the surface cleanliness of the glass. The temperature of the washing solution is generally controlled between 30-60 degrees Celsius (the water temperature heating control device should be provided by the user).

　　3、風路系統鼓風機出來的壓縮空氣經分風器分別送給上、下冷風刀及上、下熱風刀與玻璃平面之間的距離可以調整，變動玻璃厚度時，一定要注意調整此間隙。

　　3. The compressed air from the blower of the air duct system is sent to the upper and lower cold air knives and the distance between the upper and lower hot air knives and the glass plane can be adjusted. When changing the thickness of the glass, be sure to adjust this gap.

　　綜上所述，大家維護保養中空玻璃設備主要是對設備的運動、水路、風路系統方面，只要大家細心操作，注意中空玻璃加工的各個細節，肯定能夠制作出高質量的中空玻璃。

　　In summary, the maintenance of insulated glass equipment mainly focuses on the movement, water and air systems of the equipment. As long as everyone operates carefully and pays attention to the details of insulated glass processing, high-quality insulated glass can definitely be produced.

　　本文由 中空玻璃設備清洗機  友情奉獻.更多有關的知識請點擊  http://www.txxfj.com/   真誠的態度.為您提供為全面的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待.

　　This article is a friendly contribution from the hollow glass equipment cleaning machine For more related knowledge, please click http://www.txxfj.com/ Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.